auszookers.com
https://auszookers.com/forum/

wt rear diff with lockright issues
https://auszookers.com/forum/viewtopic.php?f=5&t=18444		 Page 1 of 1
Author:  shep [ Sat Jan 22, 2011 3:18 am ]
Post subject:  wt rear diff with lockright issues
my rear diff has gradually shat its self, i assumed that i had broken the pins/springs
however when i pulled it out i have found a shitload of hard black plastic
wedged into all sorts of places on the center. i cant remember anything with
plastic in the diff so i dunno how it got there.

it is possible that my young fell put something in there when i have serviced it.

any suggestions?

i have a open 2 pin centre that i can fit or i can just clean out the plastic and hope for the best
or i could weld up the lockright (1530) so what says AZ, what should i do.
Author:  89_tintop [ Sat Jan 22, 2011 3:25 am ]
Post subject:  Re: wt diff with lockright issues
Got any pics of what came out?
Author:  atari4x4 [ Sat Jan 22, 2011 3:29 am ]
Post subject:  Re: wt diff with lockright issues
are you sure one of the locals didn't fit an air locker while your were drunk on the mainland?

atari4x4 wrote:
this shows the tabs that have broken off & you can see all the dags of plastic left over from when it's come out of the mold.
Image

this one shows the crack in it...
Image

i can't believe the arb locker has farken plastic in it 8O
Author:  lump_a_charcoal [ Sat Jan 22, 2011 3:38 am ]
Post subject:  Re: wt diff with lockright issues
My guess it is bits of milk crate that found their way in...
Author:  appsie [ Sat Jan 22, 2011 3:40 am ]
Post subject:  Re: wt diff with lockright issues
the little plastic bit out near your axle seals???haha nice find in there anyway
Author:  shep [ Sat Jan 22, 2011 4:01 am ]
Post subject:  Re: wt diff with lockright issues
89_tintop wrote:
Got any pics of what came out?


i dont seen to be able to upload photos to photobucket at the moment. :?
it keeps telling me that there is a network error. :?
Author:  hutch [ Sat Jan 22, 2011 4:04 am ]
Post subject:  Re: wt diff with lockright issues
appsie wrote:
the little plastic bit out near your axle seals???haha nice find in there anyway


yeah my bet is on the axle seal keepers too. :wink:
Author:  31zook [ Sat Jan 22, 2011 4:14 am ]
Post subject:  Re: wt diff with lockright issues
hutch wrote:
appsie wrote:
the little plastic bit out near your axle seals???haha nice find in there anyway


yeah my bet is on the axle seal keepers too. :wink:


x3

just weld it up :D unless your hardcore rock crawling the 2pin will be fine :D
Author:  shep [ Sat Jan 22, 2011 4:22 am ]
Post subject:  Re: wt diff with lockright issues
hutch wrote:
appsie wrote:
the little plastic bit out near your axle seals???haha nice find in there anyway


yeah my bet is on the axle seal keepers too. :wink:



aahh i forgot about those things. funny how both sides got munched up by
the crown wheel and pinion. :?

might just put the open center in for now.
Author:  laurie [ Sat Jan 22, 2011 5:50 am ]
Post subject:  Re: wt diff with lockright issues
WARNING an open centre will make your diff quiet
Author:  Rusho [ Sat Jan 22, 2011 5:54 am ]
Post subject:  Re: wt rear diff with lockright issues
BUTTERCUP11 pompoms pompoms pompoms pompoms :woohoo: :shocked: :finger: :finger: :steamroller: :rofl:
Author:  droversdog [ Sat Jan 22, 2011 7:43 am ]
Post subject:  Re: wt rear diff with lockright issues
Mate,
I had an italian wife (no.2) that piece of plastic looks her IUD (contraceptive device). It was handed down from her grandmother, but I have no idea how it got in ur diff housing. But then she does get around a bit!
Page 1 of 1 All times are UTC + 9:30 hours
Powered by phpBB® Forum Software © phpBB Group
https://www.phpbb.com/