auszookers.com
https://auszookers.com/forum/

Fuel Tank Dent
https://auszookers.com/forum/viewtopic.php?f=5&t=28553		 Page 1 of 1
Author:  bogga [ Mon Dec 12, 2011 5:18 am ]
Post subject:  Fuel Tank Dent
Washing the mud off last night and found this big dent in the fuel tank after the weekends run.

Had about a quarter of a tank in today and my wife driving back from the shops ran out of fuel on the highway and not in a good spot. Remaining fuel couldnt be picked up due to the dent.

Now rather than filling up everytime i get to half a tank, i searched through the forum and came across this thread which describes using compressed air.
http://www.auszookers.com/index.php?nam ... nt+removal

Keen to give this a go on the weekend but do you think the dent is too big for this method. Fuel tank guard might be coming from Santa :lol:
Author:  worldo [ Mon Dec 12, 2011 5:21 am ]
Post subject:  Re: Fuel Tank Dent
could this be the reason petrol poured out when you got a bit angled in the bog hole??? i reckon it happened going up that hill.
Author:  SierraDan [ Mon Dec 12, 2011 5:21 am ]
Post subject:  Re: Fuel Tank Dent
Mine is a bit more rooted than that one and i now have the same problem!
Author:  ajsr [ Mon Dec 12, 2011 5:21 am ]
Post subject:  Re: Fuel Tank Dent
most of that will just pop out with a small amount of air
Author:  bogga [ Mon Dec 12, 2011 5:27 am ]
Post subject:  Re: Fuel Tank Dent
yeah worldo i reckon thats where it happened. also done this on the tree when going around the bog hole!!

cheers ajsr i'll give it a go this week end.
Author:  SierraDan [ Mon Dec 12, 2011 5:30 am ]
Post subject:  Re: Fuel Tank Dent
WHat i've found with the fucked up tank is i dont hit it anymore :D
Author:  Gwagensteve [ Mon Dec 12, 2011 5:34 am ]
Post subject:  Re: Fuel Tank Dent
ajsr wrote:
most of that will just pop out with a small amount of air


X2.

Compressed air is very effective. If you over do it, just tap the bulges down flat.

Steve.
Author:  suzukikid [ Mon Dec 12, 2011 5:35 am ]
Post subject:  Re: Fuel Tank Dent
Yeah mine is worse then that..... might try this to fix it though! cheers 8)
Author:  Moph [ Mon Dec 12, 2011 5:41 am ]
Post subject:  Re: Fuel Tank Dent
Just keep an eye on the tank once you've popped it out, especially for any ridges or creases. I had two tiny dings in my last tank that were only say 10mm deep each and maybe 100mm diameter, but when we went to Karijini NP and did a couple of hundred kays on rough corrugations, the ridge between the two creases ended up cracking through. Had to replace the tank.
Author:  shandy92 [ Mon Dec 12, 2011 7:00 am ]
Post subject:  Re: Fuel Tank Dent
how does this work? put the air gun nozzle in the tank with a rag around the gun?
Author:  Gwagensteve [ Mon Dec 12, 2011 7:06 am ]
Post subject:  Re: Fuel Tank Dent
That might work.

When I did one, I removed the tank first - it was holed and required welding as well as popping out.

I would disconnect the tank from the rest of the car to avoid pushing compressed air through the rest of the fuel system.

Steve.
Author:  steak_knife [ Mon Dec 12, 2011 7:10 am ]
Post subject:  Re: Fuel Tank Dent
Suzuki locking cap's like to leak out the key hole on nice angle's to..... :wink:
Author:  suzooky87 [ Mon Dec 12, 2011 7:40 am ]
Post subject:  Re: Fuel Tank Dent
YAY more Zooks in Coffs !
Should organize a suzuki meet-up/run. (sorry for being off topic)
Author:  worldo [ Mon Dec 12, 2011 7:55 am ]
Post subject:  Re: Fuel Tank Dent
Suzooky im prity keen to go somewhere on saturday if you are free.maybe bucca or where ever
Author:  SSSIERA [ Mon Dec 12, 2011 9:00 am ]
Post subject:  Re: Fuel Tank Dent
i dunno if the same principle can be applied due to the breathers and shit! but when i dent my jerries i just fill them right up and leave them in the sun on a hot day! the fuel expands and pushes them out
Author:  shandy92 [ Mon Dec 12, 2011 9:31 am ]
Post subject:  Re: Fuel Tank Dent
SSSIERA wrote:
i dunno if the same principle can be applied due to the breathers and shit! but when i dent my jerries i just fill them right up and leave them in the sun on a hot day! the fuel expands and pushes them out


dont think this would work, unless ur tank is on the roof or externaly mounted......or if ur car is upside down for any reason??
Author:  alien [ Mon Dec 12, 2011 9:39 am ]
Post subject:  Re: Fuel Tank Dent
steak_knife wrote:
Suzuki locking cap's like to leak out the key hole on nice angle's to..... :wink:


haha i had that happen the other week, interestingly the lock works smoother now, so i'm going to claim that i intentionally lubed the lock.

i've got some mean dents in my tank but they dont seem to affect the fuel pickup, however i try to fill up at 220km or so, as i know at that point ill have used 30L at the worst (usually more like 25L).
Author:  suzooky87 [ Mon Dec 12, 2011 11:35 am ]
Post subject:  Re: Fuel Tank Dent
worldo wrote:
Suzooky im prity keen to go somewhere on saturday if you are free.maybe bucca or where ever


hey mate, that sounds awesome. only i have my bucks party this W/E (going to the goldy, dreamworld followed by as many strip bars we can get to!)
I usually go out somewhere in the bush of coffs area most weekends. so maybe the following would be good ?..............oh wait thats Christmas then the next is new years then the wedding.............. we could work something out :D. sick of having to turn around cos my mate in his L series (subaru) cant get through., he needs to buy a fucking ZOOK!!!!!!!!!
Author:  worldo [ Mon Dec 12, 2011 7:00 pm ]
Post subject:  Re: Fuel Tank Dent
Haha busy month has suzooky just let me know when u are going out a.d ill come
Page 1 of 1 All times are UTC + 9:30 hours
Powered by phpBB® Forum Software © phpBB Group
https://www.phpbb.com/