| auszookers.com https://auszookers.com/forum/ |
|
| vitara reving up and down? https://auszookers.com/forum/viewtopic.php?f=5&t=33555 |
Page 1 of 1 |
| Author: | tsock0 [ Wed Jun 20, 2012 6:44 pm ] |
| Post subject: | vitara reving up and down? |
Hi all having a small problem with my lwb vitara. it seems to be reving high when in park and then it comes right down until it nearly dies and then back up high again , weird also when cruising at about 80km it sort of has a bit of a miss i just replaced my plugs and leads and was thinking i may as weel replace the dizzy cap any help would be awesome cheers |
|
| Author: | milandy [ Wed Jun 20, 2012 7:59 pm ] |
| Post subject: | Re: vitara reving up and down? |
hey tsock0 I had the same symptoms. I got a mechanic mate to clear out some stuff in the idle and I tightened the accelerator cable and put in some fuel system cleaner and I haven't seen it do it since. I also get a 'check engine' light on the highway doing speeds over 90km/h, but I have been looking around and told it is an 02 sensor issue, though I don't think this affects the issue you are having. I'd like to know if anyone else has any ideas |
|
| Author: | stockman [ Wed Jun 20, 2012 8:07 pm ] |
| Post subject: | Re: vitara reving up and down? |
Sounds like the motor is hunting. Not 100% certain, but I thing it's likely to be vacuum related. Checking that non of your hoses have come off or split would be a good starting point. |
|
| Author: | tsock0 [ Thu Jun 21, 2012 5:32 pm ] |
| Post subject: | Re: vitara reving up and down? |
alrighty thanks for the info , ill start checking these things tomorrow |
|
| Author: | Gwagensteve [ Thu Jun 21, 2012 6:27 pm ] |
| Post subject: | Re: vitara reving up and down? |
IAC can be affected by air locks in the cooling system. I had big IAC problems (hunting as you describe) and since I properly bled my cooling system, they vanished. Steve. |
|
| Author: | reeceh [ Thu Jun 21, 2012 6:41 pm ] |
| Post subject: | Re: vitara reving up and down? |
Gwagen can you please describe the correct way on bleeding the system. i realise theres no bleed nipple that i have found on my g16b. mine is in a sierra and i also have these problems. They have almost gone when i replaced the coolant and topped it right up. |
|
| Author: | Gwagensteve [ Thu Jun 21, 2012 6:46 pm ] |
| Post subject: | Re: vitara reving up and down? |
I can't comment. I have a rear mounted radiator and I have fitted a plug on the top of my thermostat housing to assist in bleeding. Steve. |
|
| Author: | reeceh [ Thu Jun 21, 2012 6:49 pm ] |
| Post subject: | Re: vitara reving up and down? |
ok thankyou |
|
| Author: | shane1992 [ Fri Jun 22, 2012 4:13 pm ] |
| Post subject: | Re: vitara reving up and down? |
Hey mate, I have had this problem too, what I done was take the radiator cap off and start the car and let it run for about 20 minutes an once it's to operationf temp I give it some revs, you will see air bubbles coming up from the coolant, hope it works for you, Shane |
|
| Author: | milandy [ Fri Jun 22, 2012 4:27 pm ] |
| Post subject: | Re: vitara reving up and down? |
I'm confused... why would the coolant affect the revs? |
|
| Author: | tsock0 [ Fri Jun 22, 2012 6:21 pm ] |
| Post subject: | Re: vitara reving up and down? |
Ok so i checked all vacumm lines and cant seem to find any leaks I hope its only an air lock like your all saying i will give that a go tommorrow Thanks all |
|
| Author: | Gwagensteve [ Sat Jun 23, 2012 6:35 pm ] |
| Post subject: | Re: vitara reving up and down? |
milandy wrote: I'm confused... why would the coolant affect the revs? Effectively the same reason coolant effects the choke on a carby car. Coolant runs up to the throttle body. Steve. |
|
| Author: | tsock0 [ Sun Jun 24, 2012 7:14 am ] |
| Post subject: | Re: vitara reving up and down? |
Well i bled the cooling system as stated before and it has helped a bit with it reving so high. Do u think i should try it again Also since i replaced plugs and leads should i do the dizzy cap and rotor button maybe? |
|
| Author: | brando93 [ Sun Jun 24, 2012 3:59 pm ] |
| Post subject: | Re: vitara reving up and down? |
Myne used to rev out to like 3000rpm upon start up then hunt between 2500 and about 3000. Turned out just to be the accelerator cable adjusted to tightly and after sorting that its been running sweet. May be something as simple as that. Id deffinately check the vacuum hoses for leaks. Also been told the maf sensor can cause similar problems but not 100% sure. |
|
| Author: | sando [ Sun Jun 24, 2012 5:51 pm ] |
| Post subject: | Re: vitara reving up and down? |
Mine was doing this and still does occasionally. Cleaned out the afm and inlet line as well as the throttle body. Checked adjustment of throttle cable, also adjusted TPS (there is a screw in the throttle body near the TPS which adjust throttle position/idle). All of these made small improvements, I then bled the coolant system and this made the biggest improvement yet. Occasionally it does carry on I believe this is because of either a little bit of air still in the coolant system or the coolant temperature. My zook runs a sierra radiator with a davis craig thermo that is wire on all the time (previous owner). In the next few weeks I will be wiring the thermos in with a temp switch and manual override switch. I will also be replacing the termostat as this could vary the temperature to much and cause the coolant temp to tell the ECU to increase/decrease idle. How long since you serviced the cooling system? |
|
| Author: | alien [ Sun Jun 24, 2012 11:15 pm ] |
| Post subject: | Re: vitara reving up and down? |
mine hunts on idle on cold mornings - on a really cold morning it will rev from 1000rpm down to almost stalling - it'll do this only while its between cold and warm on the temp gauge - for about 5mins if its just sitting in the driveway. It has also outright just stalled a few times too - hunted a few times then just carked it. I'd love to know what the solution is, but thus far i've got no idea! it is very repeatable though... but only on a cold start on a morning below 10*C. |
|
| Author: | reeceh [ Mon Jun 25, 2012 4:17 pm ] |
| Post subject: | Re: vitara reving up and down? |
I have the g16b in my sierra with same problems. I have stripped off the throttle body to find the area where the coolant runs through it is totally blocked up. Its currently soaking in petrol to hopefully free it up so the coolant can run properly through there. |
|
| Author: | alien [ Mon Jun 25, 2012 7:22 pm ] |
| Post subject: | Re: vitara reving up and down? |
mmm interesting... keep us updated! I wouldnt think mine would be blocked, only having 20,000km on it... but ya never know. |
|
| Author: | reeceh [ Wed Jun 27, 2012 8:23 pm ] |
| Post subject: | Re: vitara reving up and down? |
anyone have a easy way of cleaning the coolant inlet in the throttle body. Ive had this soaking in petrol for 2 days with constant sprays of throttle body cleaner down there but it is still blocked. |
|
| Author: | sando [ Thu Jun 28, 2012 5:36 am ] |
| Post subject: | Re: vitara reving up and down? |
Tried compressed air? |
|
| Author: | reeceh [ Thu Jun 28, 2012 11:12 am ] |
| Post subject: | Re: vitara reving up and down? |
Yeah. Pretty blocked |
|
| Author: | shandy92 [ Sat Jun 30, 2012 3:33 pm ] |
| Post subject: | Re: vitara reving up and down? |
when i first got my vit (g16b) had similar issues, took it to a mech who took the throttle body off and it was completely blocked. there is no real easy way to remove dried coolant. you could fit a new Throttle body or scrape it out ahaha. i got a new one 
|
|
| Author: | reeceh [ Sat Jun 30, 2012 4:45 pm ] |
| Post subject: | Re: vitara reving up and down? |
Where did you source a new one mate?? |
|
| Author: | sando [ Sat Jun 30, 2012 8:45 pm ] |
| Post subject: | Re: vitara reving up and down? |
Still no luck reeceh? Can you drill it or scrape it out at all? Where abouts in Brisbane are you? I might be able to give you a hand if you want depending on location. |
|
| Author: | reeceh [ Sat Jun 30, 2012 9:19 pm ] |
| Post subject: | Re: vitara reving up and down? |
There's no good access to it! It's been soaking in petrol since Monday. It's too hard to shove wire down there. Im at my gravatt! Ill be calling suzisport on Monday to see what they do or if they have another throttle body. |
|
| Author: | tsock0 [ Thu Jul 05, 2012 6:10 pm ] |
| Post subject: | Re: vitara reving up and down? |
right , so the throttle body could be blocked sounds like a shit of a job, keep us posted with the best way to clean this or a price on a new one |
|
| Author: | reeceh [ Thu Jul 05, 2012 8:25 pm ] |
| Post subject: | Re: vitara reving up and down? |
|
|
| Page 1 of 1 | All times are UTC + 9:30 hours |
| Powered by phpBB® Forum Software © phpBB Group https://www.phpbb.com/ |
|