auszookers.com
https://auszookers.com/forum/

Rattling transfer case.
https://auszookers.com/forum/viewtopic.php?f=5&t=34677		 Page 1 of 1
Author:  Joshua02 [ Thu Aug 02, 2012 3:54 pm ]
Post subject:  Rattling transfer case.
On sunday I towed my brothers car for 50 metres and ever since my transfer case rattles like crazy is there any common known reasons its a 96 sierra.
Author:  Bruce [ Thu Aug 02, 2012 4:06 pm ]
Post subject:  Re: Rattling transfer case.
Rattles as in rattles inside or the stick moves around?
More info needed.
Author:  Joshua02 [ Thu Aug 02, 2012 4:18 pm ]
Post subject:  Re: Rattling transfer case.
The stick just moves like crazy and it only does it in 2nd gear and up.
Author:  abclarke [ Thu Aug 02, 2012 4:37 pm ]
Post subject:  Re: Rattling transfer case.
*sits back and waits for coily jokes* :lol:
Author:  Bruce [ Thu Aug 02, 2012 4:41 pm ]
Post subject:  Re: Rattling transfer case.
Check the t/case mounts for a start.
Author:  Joshua02 [ Thu Aug 02, 2012 5:02 pm ]
Post subject:  Re: Rattling transfer case.
Yeah mounts are tight just double checked them.
Author:  BenT [ Thu Aug 02, 2012 5:12 pm ]
Post subject:  Re: Rattling transfer case.
Bent transfer case mounting arms would be my guess, or, broken mounting rubbers.

Ben
Author:  Joshua02 [ Thu Aug 02, 2012 5:32 pm ]
Post subject:  Re: Rattling transfer case.
Mounts look fine no damage slight wear in rubber dampene, its doing it in 2h 4H &4L starts at 20 kph.
Author:  BenT [ Thu Aug 02, 2012 5:43 pm ]
Post subject:  Re: Rattling transfer case.
Joshua02 wrote:
Mounts look fine no damage slight wear in rubber dampene, its doing it in 2h 4H &4L starts at 20 kph.


Its not always really obvious if the long side arm has twisted, but when they do it puts the angles on the drive shafts out and causes vibrations like you describe.
Author:  Joshua02 [ Fri Aug 03, 2012 12:16 pm ]
Post subject:  Re: Rattling transfer case.
how can it twist I wasn't 4wding? Is there replacement arms ?
Author:  stockman [ Fri Aug 03, 2012 12:26 pm ]
Post subject:  Re: Rattling transfer case.
Joshua02 wrote:
how can it twist I wasn't 4wding? Is there replacement arms ?


But you were towing a car which puts a lot more stress on the drive line.
Author:  Joshua02 [ Fri Aug 03, 2012 12:59 pm ]
Post subject:  Re: Rattling transfer case.
Uhh shit alright makes sense so that would twist the arm?
Author:  JrZook [ Fri Aug 03, 2012 1:00 pm ]
Post subject:  Re: Rattling transfer case.
Still sounds like a tcase mount. Put it in low range, 1st gear, put your foot on the brake and slowly let the clutch out until it stalls. If the tcase stick moves a shit load you have a buggered mount
Author:  Joshua02 [ Fri Aug 03, 2012 1:09 pm ]
Post subject:  Re: Rattling transfer case.
JrZook wrote:
Still sounds like a tcase mount. Put it in low range, 1st gear, put your foot on the brake and slowly let the clutch out until it stalls. If the tcase stick moves a shit load you have a buggered mount


The thing is it only starts rattling when im doing 20 kph and just gets worst and worst. ?
Author:  atari4x4 [ Fri Aug 03, 2012 1:13 pm ]
Post subject:  Re: Rattling transfer case.
stretched transfercase chain... it's a coily right?
Author:  Joshua02 [ Fri Aug 03, 2012 1:25 pm ]
Post subject:  Re: Rattling transfer case.
atari4x4 wrote:
stretched transfercase chain... it's a coily right?

yeah she is a coily how difficult are the chains to replace and get ahold of ?
Author:  Jfuit94 [ Mon Aug 06, 2012 8:27 pm ]
Post subject:  Re: Rattling transfer case.
im having a similar problem in my 85 drover. would it be the same. i dont have much knowledge about zooks or cars in general, to start with i thought it was my drive shaft, still havent ruled that out
Page 1 of 1 All times are UTC + 9:30 hours
Powered by phpBB® Forum Software © phpBB Group
https://www.phpbb.com/