auszookers.com
https://auszookers.com/forum/

Can any one tell me how to swap out a elec fuel pump to mech
https://auszookers.com/forum/viewtopic.php?f=5&t=38173		 Page 1 of 1
Author:  Jake terry [ Mon Jan 07, 2013 7:50 pm ]
Post subject:  Can any one tell me how to swap out a elec fuel pump to mech
I hav a electric fuel pump and it keeps flooding the motor and now I have a mechanical pump and I don't know how to put it on if any one has any diagrams thanks
Author:  fordem [ Tue Jan 08, 2013 7:30 am ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
Is there a blanking plate on the right rear corner of the head? That's where it fits - you remove the blanking plate and fit the pump in it's place - there's also a "push rod" that goes between the pump and the cam, make sure it's there. Hook up the lines (there are three), the fuel line from the tank, the return line to the tank, and the fuel line to the carb.
Author:  Rusho [ Tue Jan 08, 2013 9:47 am ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
Or buy a regulator for the electric pump....would be less hastle andante cheaper 8)
Author:  Rusho [ Tue Jan 08, 2013 9:47 am ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
Or buy a regulator for the electric pump....would be less hastle andante cheaper 8)
Author:  kenn [ Tue Jan 08, 2013 12:32 pm ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
Or fix the carby
Author:  Jake terry [ Tue Jan 08, 2013 1:23 pm ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
It's a recond carby. And how much are the regulators
Author:  Gwagensteve [ Tue Jan 08, 2013 1:45 pm ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
Just put the mechanical pump back on and forget about the electric pump.

Image

Here's a diagram.

The hose associated with the clamp marked 17 goes to the carby
The hose associated with clamp marked 25 is 6mm diameter hose and it's the return to the tank
The hose above that is 8mm and is the supply from the tank.
You'll need item 2 which is the pushrod.

The pump is located at the back of the cylinder head on the driver's side.

you can see it here:

Image
The hose going forwards to the carby is obscured in this photo.

Steve.

PS if you don't have a genuine suzuki mechanical pump, get one. The aftermarket pumps are rubbish. I was told this by someone who used to sell them.
Author:  Jake terry [ Tue Jan 08, 2013 1:52 pm ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
I got a brand one . Say where u put the pump would the pin still be in there if it was plated off
Author:  Gwagensteve [ Tue Jan 08, 2013 2:18 pm ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
I doubt it, but you'll have to have a look. They're not retained at all - they just slide out if the pump is removed.

Steve.
Author:  Jake terry [ Tue Jan 08, 2013 2:30 pm ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
Damn ok
Author:  hooki [ Wed Jan 09, 2013 4:12 am ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
Hey jake I found the pin on the ground, it must have fallen out when I removed that pump for you.
Author:  Jake terry [ Wed Jan 09, 2013 4:22 am ]
Post subject:  Re: Can any one tell me how to swap out a elec fuel pump to
Bugger ok thanks
Page 1 of 1 All times are UTC + 9:30 hours
Powered by phpBB® Forum Software © phpBB Group
https://www.phpbb.com/