It is currently Thu Jul 23, 2026 6:03 am
Board index » Talking About Stuff » Suzuki Talk



Post new topic Reply to topic  [ 15 posts ] 
Author Message

Offline
User avatar

Joined: Fri Jan 16, 2009 10:30 pm
Posts: 351
Location: BRISBANE!!!

Post Posted: Tue Apr 14, 2009 11:57 pm 
Reply with quote Top  
i finally got my drover back together after installing a new water pump, thermostat, second fuel filter and spark plugs...

( i also swapped over my old and tired fuel pump for a secondhand one of unknown condition which seemed to work the same mechanically as the old one outside the car)

and when i turn the ignition after dropping some fuel into the carby it the engine revs hard and climbs to about 2/3000rpms then cuts out...

there is no fuel visibly getting through the lines to the second fuel filter... could it be anything else other than the mystery fuel pump?

just wanna check before pulling it out again...

 Profile  

Offline
omnipotent being
omnipotent being
User avatar

Joined: Sun Jun 11, 2006 11:30 pm
Posts: 17216
Location: Pluto

Post Posted: Tue Apr 14, 2009 11:59 pm 
Reply with quote Top  
got the lines on correctly?

sometimes it can take a few goes to get teh pump to prime as well, give it a few goes or try to feed some fuel into the carb to get teh float bowl full

 Profile  

Offline
User avatar

Joined: Wed May 21, 2008 11:30 pm
Posts: 4972
Location: Dandenong .Vic
Vehicle: 1999 GV. Locked and Lifted

Post Posted: Wed Apr 15, 2009 12:11 am 
Reply with quote Top  
Have you replaced the filter at the tank as it might be blocked. pull the fuel line to the carby off and put it into a small container and crank it over. that will test if there is fuel flow

 Profile  

Offline
User avatar

Joined: Fri Jan 16, 2009 10:30 pm
Posts: 351
Location: BRISBANE!!!

Post Posted: Wed Apr 15, 2009 12:17 am 
Reply with quote Top  
yep replaced the tank filter, and given it a few goes just doube checked the lines... all on correct... however there is a pipe coming off the bottom of the installed fuel pump that wasnt on the initial one... couldnt figure out what it was for... comes out of the left hole directly below the 'in' fuel line...

_________________
[quote="zookieboi"]has anyone really been far even

 Profile  

Offline
omnipotent being
omnipotent being
User avatar

Joined: Sun Jun 11, 2006 11:30 pm
Posts: 17216
Location: Pluto

Post Posted: Wed Apr 15, 2009 12:24 am 
Reply with quote Top  
thats a vent, nothing goes on there

 Profile  

Offline
User avatar

Joined: Wed May 21, 2008 11:30 pm
Posts: 4972
Location: Dandenong .Vic
Vehicle: 1999 GV. Locked and Lifted

Post Posted: Wed Apr 15, 2009 12:27 am 
Reply with quote Top  
cant remember what that was connected to.

 Profile  

Offline
User avatar

Joined: Fri Jan 16, 2009 10:30 pm
Posts: 351
Location: BRISBANE!!!

Post Posted: Wed Apr 15, 2009 12:41 am 
Reply with quote Top  
cool cool... :( will go swap the fuel pump for the old one... see if that works...

_________________
[quote="zookieboi"]has anyone really been far even

 Profile  

Offline
az supporter
az supporter
User avatar

Joined: Tue Jul 15, 2008 11:30 pm
Posts: 8203
Location: Melbourne
Vehicle: Pajero 91 NH 3.0 SWB

Post Posted: Wed Apr 15, 2009 12:50 am 
Reply with quote Top  
There is a rod, in the head, (cam pushes on it to operate pump)
that can slide out and fall on the ground, as soon as You're not looking.
I have been tricked by that before, best to check.

christover

_________________
VIC ZOOK CLUB
http://www.vic.suzuki4wd.com/forum/

 Profile  

Offline

Joined: Sun Aug 13, 2006 11:30 pm
Posts: 889
Location: Brisbane

Post Posted: Wed Apr 15, 2009 1:43 am 
Reply with quote Top  
I too have fallen for the old fuel pump rod gone missing trick.

I didn't even know it existed when a friend asked me if i had put it back in.

 Profile  

Offline
User avatar

Joined: Fri Jan 16, 2009 10:30 pm
Posts: 351
Location: BRISBANE!!!

Post Posted: Wed Apr 15, 2009 1:58 am 
Reply with quote Top  
ahah luckily i didnt have to pull the head apart... just dropped the old fuel pump in works a treat... just need to fix a few more leaky hoses and tighten the exhaust manifold and... heres the kicker...
now that ive got it running smooth and no messy idling... the camshaft pulley is smacking against the housing so it is rubbing and heating up... it stops when it is pushed back towards the head but i cant seem to shift the housing so its not interfering with the pulley... loosened all the visible bolts and retightened them evenly and still it hits... :( anything else i seem to be missing?

_________________
[quote="zookieboi"]has anyone really been far even

 Profile  

Offline
omnipotent being
omnipotent being
User avatar

Joined: Sun Jun 11, 2006 11:30 pm
Posts: 17216
Location: Pluto

Post Posted: Wed Apr 15, 2009 2:01 am 
Reply with quote Top  
you mean the cover? if its the bit behind the pulley there is a rubber bit gets caught in there, if you mean the front bit the rubber bit still gets in teh way and you can put the cover on wrong so it hits but seems like its on right, pull it off and put it back on with less force

if the belt is running off the pulley and rubbing the pulley is probably bent

 Profile  

Offline
az supporter
az supporter
User avatar

Joined: Tue Jul 15, 2008 11:30 pm
Posts: 8203
Location: Melbourne
Vehicle: Pajero 91 NH 3.0 SWB

Post Posted: Wed Apr 15, 2009 2:04 am 
Reply with quote Top  
Mine did that, a new motor was fitted recently.
They had used a rubber gasket that was too thick, in behind the small steel plate that the timing cover bolts to.
It wasn't a problem at 1st, but it slowly warped the cover.

_________________
VIC ZOOK CLUB
http://www.vic.suzuki4wd.com/forum/

 Profile  

Offline
az supporter
az supporter
User avatar

Joined: Tue Jul 15, 2008 11:30 pm
Posts: 8203
Location: Melbourne
Vehicle: Pajero 91 NH 3.0 SWB

Post Posted: Wed Apr 15, 2009 2:08 am 
Reply with quote Top  
After disassembly of entire timing belt etc,
it was found to be a rubber gasket,
behind the rear piece that timing belt cover fits to.
It was too thick, thus it was slowly distorting the cover,
till it hit the timing pulley.

Image

Image

_________________
VIC ZOOK CLUB
http://www.vic.suzuki4wd.com/forum/

 Profile  

Offline
User avatar

Joined: Fri Jan 16, 2009 10:30 pm
Posts: 351
Location: BRISBANE!!!

Post Posted: Wed Apr 15, 2009 2:22 am 
Reply with quote Top  
sweet cheers for the info! will have to pull it off an check the gasket and pulley tomorrow after work... damn thought i'd get to drive myself to work tomorrow!

_________________
[quote="zookieboi"]has anyone really been far even

 Profile  

Offline
User avatar

Joined: Fri Jan 16, 2009 10:30 pm
Posts: 351
Location: BRISBANE!!!

Post Posted: Thu Apr 16, 2009 1:15 am 
Reply with quote Top  
i seem to have had the same problem as youchistover1 adjusted the gasket and loosened the housing slightly more at the top and no more banging... will have to get proper gasket soon....
is it just me or does your engine always seem quieter and smoother once its back together...?
oh well have fun!

_________________
[quote="zookieboi"]has anyone really been far even

 Profile  
Display posts from previous:  Sort by  
Post new topic Reply to topic  [ 15 posts ] 

Jump to:  


Who is online

Users browsing this forum: No registered users and 91 guests

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum
Untitled Document


Untitled Document


Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group :: Style based on FI Subice by phpBBservice.nl :: All times are UTC + 9:30 hours