It is currently Wed Jul 29, 2026 11:11 am
Board index » Talking About Stuff » Suzuki Talk



Post new topic Reply to topic  [ 24 posts ] 
Author Message

Offline
User avatar

Joined: Tue Mar 24, 2009 10:30 pm
Posts: 9242
Location: maito
Vehicle: <3 Edna <3

Post Posted: Sun Aug 15, 2010 6:22 am 
Reply with quote Top  
I installed a suby MC today, it works, but no better then before and i think my brakes are dragging now. What could have caused this? It's on a 1.3 WT (so boosted)

other info that may help, i have a willwood prop valve, and the piston lenght has been set by the guy before me who used it in his boosted zook. Could it be that the piston is jamed or not returning due to being stiff or un-lubed?

Im fairly lost and i need my car for tomorrow....

cheers :(

 Profile  

Offline
az supporter
az supporter
User avatar

Joined: Sun May 04, 2008 11:30 pm
Posts: 9716
Location: NSW
Vehicle: SJ51 LWB, SJ70 SWB

Post Posted: Sun Aug 15, 2010 7:08 am 
Reply with quote Top  
My front brakes have dragged before, They were seized with dirt..

Once they were cleaned out and rubber greased, they were fine again.

The system should run un-pressurised..Because your foot gives the pressure..

_________________
BlueSuzy wrote:
I'm over the G16b's.

 Profile  

Offline
User avatar

Joined: Wed Oct 21, 2009 10:30 pm
Posts: 477
Location: ballarat

Post Posted: Sun Aug 15, 2010 7:14 am 
Reply with quote Top  
if the slide on the caliper is seazed they will drag

 Profile  

Offline
omnipotent being
omnipotent being
User avatar

Joined: Sun Jun 11, 2006 11:30 pm
Posts: 17216
Location: Pluto

Post Posted: Sun Aug 15, 2010 7:30 am 
Reply with quote Top  
crack a bleed screw to see if there is any residual pressure there front and rear, should be none on the front and a little on the rear (to hold the wheel cylinders out a bit)

If there is the master cyl might not be returning fully, or you have front and rear mixed up :)

 Profile  

Offline
User avatar

Joined: Tue Jul 28, 2009 11:30 pm
Posts: 455
Location: Newcastle NSW
Vehicle: I drive your mum

Post Posted: Sun Aug 15, 2010 7:34 am 
Reply with quote Top  
Have you checked each brake caliper/drum bleed nipple for residual pressure? Take the zook for a drive round the block, come back and leaving the engine running crack each brake bleed nipple. If one squirts out under pressure you have found your line that is holding pressure. If none squirt out then there should be no residual pressure in the system, so your brake dragging may be from the usual causes (sticking pins/slides, failed drum components etc).


Note: you will need to re-bleed your brakes after you test this.


Layto....

 Profile  

Offline
User avatar

Joined: Tue Mar 24, 2009 10:30 pm
Posts: 9242
Location: maito
Vehicle: <3 Edna <3

Post Posted: Sun Aug 15, 2010 8:22 am 
Reply with quote Top  
before it was working fine, like no drag and would roll on a flat surface.

something else i should put in is that the brake pedal has no play in it, it is all force from the first touch of the pedal.... is that right?

 Profile  

Offline
az supporter
az supporter
User avatar

Joined: Tue Aug 01, 2006 11:30 pm
Posts: 3461
Location: licking some windows
Vehicle: LJ20 LJ50

Post Posted: Sun Aug 15, 2010 8:29 am 
Reply with quote Top  
31zook wrote:
before it was working fine, like no drag and would roll on a flat surface.

something else i should put in is that the brake pedal has no play in it, it is all force from the first touch of the pedal.... is that right?


no

_________________
Camels have nice toes

 Profile  

Offline
az supporter
az supporter
User avatar

Joined: Sun Nov 16, 2008 10:30 pm
Posts: 208
Location: Nelson, NZ
Vehicle: 85 SJ413

Post Posted: Sun Aug 15, 2010 8:36 am 
Reply with quote Top  
31zook wrote:
I installed a suby MC today, it works, but no better then before and i think my brakes are dragging now. What could have caused this? It's on a 1.3 WT (so boosted)


I bet the push rod between the booster and master cylinder is too long and you have no free play in your pedal so its holding the piston in all the time.

Ben

_________________
WWW.ZUKPARTS.COM - Quality Suzuki Off-road Parts

 Profile WWW  

Offline
az supporter
az supporter
User avatar

Joined: Sat Oct 24, 2009 10:30 pm
Posts: 845
Location: Melbourne

Post Posted: Sun Aug 15, 2010 9:49 am 
Reply with quote Top  
Exactly as Ben said, you need to fab up youre own length rod out of a bolt or whatever. You must have a teeny amount of play.

 Profile  

Offline
User avatar

Joined: Tue Mar 24, 2009 10:30 pm
Posts: 9242
Location: maito
Vehicle: <3 Edna <3

Post Posted: Sun Aug 15, 2010 11:24 am 
Reply with quote Top  
ok, i have been all through my FSM to try to understand how they work better, and i have two last questions,

can the push rod be misaligned?

does anyone know how to work out the right length or know the correct length for the push rod?

 Profile  

Offline
omnipotent being
omnipotent being
User avatar

Joined: Sun Jun 11, 2006 11:30 pm
Posts: 17216
Location: Pluto

Post Posted: Sun Aug 15, 2010 11:35 am 
Reply with quote Top  
distance from master mounting face on the booster to the cup where the push rod site plus the same on the master side minus a bit?

if its too long now its all bled if you undo the nuts holding it to the booster it should sit away from teh booster a bit, this amount might be a good start :)

 Profile  

Offline
User avatar

Joined: Tue Mar 24, 2009 10:30 pm
Posts: 9242
Location: maito
Vehicle: <3 Edna <3

Post Posted: Sun Aug 15, 2010 11:44 am 
Reply with quote Top  
I wondered if i could just undo the booster nuts and slip it away from the booster.... thus not having to bleed my brakes again.... also you make a good point royce, that is so flipping logical with the way you would measure it, i don't know why i didn't think of it...

 Profile  

Offline
User avatar

Joined: Tue Mar 24, 2009 10:30 pm
Posts: 9242
Location: maito
Vehicle: <3 Edna <3

Post Posted: Sun Aug 15, 2010 10:38 pm 
Reply with quote Top  
Ok i undone the booster bolts slipped it forward and shortened the push rod by not much, but enough to make the brakes not drag, so im :D about that.

But shouldn't this set up work better then stock? I sort of expected minimal effort for big braking power, but it's the same if not more effort and the same braking force..... It has a prop valve on the back btw, do i need to loosen that off? or should nearly all the brakes be at the front?

Im only on 205/75s... :(

 Profile  

Offline
omnipotent being
omnipotent being
User avatar

Joined: Sun Jun 11, 2006 11:30 pm
Posts: 17216
Location: Pluto

Post Posted: Sun Aug 15, 2010 10:45 pm 
Reply with quote Top  
Arent the subi ones a larger bore? larger bore = less effort generated at the wheels for a given input pressure but it needs less pedal travel to do so

 Profile  

Offline
User avatar

Joined: Thu Feb 26, 2009 10:30 pm
Posts: 13007
Location: Melbourne

Post Posted: Sun Aug 15, 2010 10:52 pm 
Reply with quote Top  
royce wrote:
Arent the subi ones a larger bore? larger bore = less effort generated at the wheels for a given input pressure but it needs less pedal travel to do so


Exactly. The advantage of the Subaru cylinder is a higher harder pedal and better proportioning. Pedal effort will be higher, that doesn't mean your brakes are "worse"

Steve

 Profile  

Offline
User avatar

Joined: Tue Mar 24, 2009 10:30 pm
Posts: 9242
Location: maito
Vehicle: <3 Edna <3

Post Posted: Sun Aug 15, 2010 11:03 pm 
Reply with quote Top  
ok, well i guess i didn't get what i was expecting, and thats ok, as long as im not sitting on a ticking time bomb....

so what would make less effort and more wheel power?

 Profile  

Offline
omnipotent being
omnipotent being
User avatar

Joined: Sun Jun 11, 2006 11:30 pm
Posts: 17216
Location: Pluto

Post Posted: Sun Aug 15, 2010 11:06 pm 
Reply with quote Top  
smaller mastercyl, at the expense of longer pedal travel

or a bigger booster, but youll lose feel

better bet still is vented vitara fronts with quality pads

 Profile  

Offline
User avatar

Joined: Tue Mar 24, 2009 10:30 pm
Posts: 9242
Location: maito
Vehicle: <3 Edna <3

Post Posted: Sun Aug 15, 2010 11:09 pm 
Reply with quote Top  
or joeblows rear disk kit, with pintara calipers.... ok, ill fuss with teh rest later. good to know its all working how it should :D

 Profile  

Offline
omnipotent being
omnipotent being
User avatar

Joined: Sun Jun 11, 2006 11:30 pm
Posts: 17216
Location: Pluto

Post Posted: Mon Aug 16, 2010 12:04 am 
Reply with quote Top  
front brakes do more for stopping than rears, do them first :wink:

 Profile  

Offline

Joined: Sat Jul 18, 2009 11:30 pm
Posts: 2372
Location: Ballarat, VIC

Post Posted: Mon Aug 16, 2010 12:15 am 
Reply with quote Top  
royce wrote:
smaller mastercyl, at the expense of longer pedal travel

or a bigger booster, but youll lose feel

better bet still is vented vitara fronts with quality pads


+1
The vented vit fronts and factory pads on it, is the way to go.
The braking is fantastic.

It is a modification which should be done when putting bigger tyres on.

 Profile  

Offline
User avatar

Joined: Tue Mar 24, 2009 10:30 pm
Posts: 9242
Location: maito
Vehicle: <3 Edna <3

Post Posted: Mon Aug 16, 2010 1:40 am 
Reply with quote Top  
sweet stuff, where do you get these kit's from? is this the sort after lwb 16v front brake calipers?

 Profile  

Offline
omnipotent being
omnipotent being
User avatar

Joined: Sun Jun 11, 2006 11:30 pm
Posts: 17216
Location: Pluto

Post Posted: Mon Aug 16, 2010 2:02 am 
Reply with quote Top  
yep thats it, grab some calipers from a wreck, new rotors and pads and you are away

 Profile  

Offline
User avatar

Joined: Tue Mar 24, 2009 10:30 pm
Posts: 9242
Location: maito
Vehicle: <3 Edna <3

Post Posted: Mon Aug 16, 2010 2:54 am 
Reply with quote Top  
cool beans :D

 Profile  

Offline
az supporter
az supporter

Joined: Tue May 27, 2008 11:30 pm
Posts: 1791
Location: Central coast NSW

Post Posted: Mon Aug 16, 2010 8:36 am 
Reply with quote Top  
a bigger booster will make the pedal easier to push down. i have no idea what booster you would use.

that what your after aren't you?

 Profile  
Display posts from previous:  Sort by  
Post new topic Reply to topic  [ 24 posts ] 

Jump to:  


Who is online

Users browsing this forum: No registered users and 554 guests

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum
Untitled Document


Untitled Document


Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group :: Style based on FI Subice by phpBBservice.nl :: All times are UTC + 9:30 hours